一、產品簡介：
酸純化器：又稱酸純化系統，高純酸提純器，酸試劑提純器，高純酸蒸餾純化器等，實驗室工作中常常由于酸的純度較差，造成分析結果的偏差與錯誤。市售的超純酸往往由于價格較貴，很難滿足日常分析中對酸的大量需求。因此，提純優化酸的質量，是為經濟可行的途徑，我廠的酸純化器可用于實驗室如HNO3、HCl、HF、堿溶液和有機溶劑的純化，純化后的酸和Merck的一樣好，實驗后期可配套我單位Teflon特氟龍系列試劑瓶收取高純酸。
I. product introduction:
Acid purifier: also known as acid purification system, high purity acid purifier, acid reagent purifier, high purity acid distillation purifier, etc., often due to the poor purity of acid in the laboratory work, resulting in the deviation and error of the analysis results. Due to the high price, it is difficult to meet the large demand for acid in daily analysis. Therefore, purification and optimization of acid quality is the most economical and feasible way. Our acid purifier can be used for purification of laboratory such as HNO3, HCl, HF, alkali solution and organic solvent. The purified acid is as good as Merck's.
二、工作原理：
酸純化器是利用熱輻射原理，保持液體溫度低于沸點溫度蒸發，再將其酸蒸氣冷凝從而制備高純水和高純?cè)噭?，廣泛應用于樣品處理及分析實驗中。
Ii. Working principle
Acid purifier is the use of heat radiation principle, keep the temperature of the liquid below the boiling point temperature evaporation, and then its acid vapor condensation to prepare high purity water and high purity reagent, widely used in sample processing and analysis experiments.
三、產品特點：
1、可以滿足ICP、ICP-MS極低的檢測限需要及苛刻的分析應用中提供實驗室級超純酸，所用容器均采用Teflon耐腐蝕無吸附塑料，可處理如HNO3、HCl、HF等實驗室的常用酸。
2、實驗證明將金屬雜質含量約10ppb的酸經過一次蒸餾后，金屬雜質含量可以降低到0.01ppb左右。若對酸要求更高，可增加提純次數。
Iii. Product features
1. It can meet the extremely low detection limit requirements of ICP and icp-ms and provide lab-level ultra-pure acid in demanding analytical applications. All containers used are made of Teflon corrosion-resistant and non-adsorption plastics, which can deal with common acids in laboratories such as HNO3, HCl and HF.
2. The experiment proved that the metal impurity content could be reduced to about 0.01 PPB after the acid with the metal impurity content of about 10ppb was distilled once. If the requirement of acid is higher, The Times of purification can be increased.
四、技術參數：
型號QYSCH-1QYSCH-2QYSCH-3容積大小500ml1000ml2000ml產酸率30ml/h50ml/h70ml/h溫控方式PID溫控?cái)?shù)顯控溫精度±1℃
材質FEP、PTFE、硅膠電壓220V/50Hz功率（W）380優勢1.密閉環境下提純酸，不受環境污染，確保酸純度2.純FEP、PTFE材質制造，空白值低無腐蝕3.技術先進，結構合理，操作簡單，一鍵式操作，蒸干自我保護4.提純過程中，極少量酸氣逸出5.節約成本，方便實驗：較短時間內純化低成本的酸試劑以達到痕量分析要求