1
產品說明Product instructions
本產品是以高分子聚合物材料、特種水泥、礦物填料、外加助劑等為原料，配置而成的一種全新型干粉砂漿，具有施工性能優異，操作簡單、環保、可靠性能，要適合于混凝土地面修補、薄層找平。
This product is made of polymer polymer materials, special cement, mineral fillers, additive additives, etc. as raw materials, accurate configuration of a new type of dry powder mortar, with excellent construction performance, simple operation, environmental protection, non-toxic, safe and reliable performance, To be suitable for concrete surface repair, thin layer to find flat.
2
產品類型 Product type
一 、按使用性能可分為兩大類：
Products can be divided into two major categories through use performance:
1 抹平型修補砂漿 Scratch repair mortar
2 流平型修補砂漿 Liquidity repair mortar
二 、按顏色可分為：紅色、綠色、天藍色、寶藍色、黑色、灰色、黃色。
According to the color can be divided into: red, green, sky blue, blue, black, gray, yellow.
3
產品參數Product parameters
4
產品特性Productcharacteristics
1 本產品具有粘結強度高、收縮小、抗壓強度高、耐候性好、物理性能穩定，有很好的保水性能和抗裂性。
The product has high bond strength, shrinkage, high compressive strength, good weather resistance, stable physical properties, and good water retention and cracking resistance.
2 對改造的硬化混凝土地坪修補，常溫可控1天內進行研磨拋光，顏色可調，可達到和原混凝土接近，特別適合裝飾混凝土的修補。
For the modification of the hardened concrete floor repair, grinding and polishing can be carried out within 1 day of room temperature control, and the color can be adjusted. It can be close to the original concrete and is especially suitable for decoration concrete repair.
5
產品規格Product specifications
產品包裝
25公斤/包 密封編織袋包裝
Product packaging: 25 kg/package sealed woven bag packaging
6
適用范圍Scope of application
1 新舊混凝土地面裂縫修補
Repair of ground cracks in old and new concrete.
2 新舊混凝土地面坑洞、麻點修補
Old and new concrete ground pit, hemp spot repair.
3 起灰起砂、強度嚴重偏低的混凝土地面面層薄層修補
Thin layer repair of concrete surface layer with low strength and ash.
4 坑洼混凝土地面厚層找平修補
Pit concrete ground thick layer finds flatten repair.
7
施工工藝Product use
抹平型修補砂漿
Scratch repair mortar
產品適用說明Application
抹平型修補砂漿主要適用于混凝土地面的裂縫、坑洞、麻點及坑洼修補。
leveling type repair mortar is mainly used for the repair of cracks, potholes, potholes andpotholes in concrete.
施工工藝Product use
A 清潔混凝土地面表面
Clean the concrete surface
B 對混凝土地面進行勘察，找出需要修補的裂縫、坑洞、麻點及坑洼地方。
Survey the concrete floor to find cracks, potholes, spots and potholes that need to be repaired
C 對需要修補的地方進行清潔，裂縫的地方需要進行切割。
Clean the areas that need repairing and cut the cracks
D 清潔或切割好的需要修補地面，用清水浸泡2小時以上，確保地面完全濕潤。
The ground should be repaired after cleaning or cutting, and soaked with water for more than 2 hours to ensure the ground is completely wet
E 根據修補地面的面積大小，量取修補材料，加入適量的水進行攪拌。
Measure the repair material according to the area of the repaired ground and add proper amount of water for stirring
F 修補砂漿的用量：1.7公斤/平方/毫米，水灰比：1:0.2-0.25，一定要將修補砂漿攪拌均勻成糊狀。
Repair mortar dosage: 1.7kg/square/mm, water-cement ratio: 1:0.2-0.25, be sure to mix the repaired mortar evenly into a paste
G 將攪拌好的修補砂漿倒入需要修補的地面，用抹子抹平，注意地面不得有明顯的積水。
Pour the mixed mortar into the ground to be repaired, and wipe it with a brush
H 在抹平的過程中，不得反復來回抹平砂漿，同時修補砂漿應高出補修補的平面。
In the process of leveling, the mortar shall not be rubbed back and forth repeatedly, and the mortar shall be repaired higher than the patched plane
I 修補砂漿為快干型修補砂漿，由于產品加入保水劑，在干燥的過程中，不易澆水養護。
Repair mortar is quick dry type repair mortar, because the product adds the water-retaining agent, in the drying process, not easy watering maintenance
J 待修補砂漿干燥后，強度完全起來時，采用手磨機或研磨機磨平被修補的地面即可。
When the mortar is dry after being repaired and the strength is completely up, the ground that is repaired can be ground smooth by hand grinder or grinder
注意事項Matters needing attention
1 如被修補的地面要求修補部分與原地面的顏色一致，可通過在修補砂漿中加入適量的色粉進行調色，色粉本公司可以提供。
If the repaired ground is required to be the same color as the original surface, the color can be adjusted by adding appropriate amount of color powder to the repaired mortar, which can be provided by our company
2 對于重載地面修補，被修補的地面在上修補砂漿材料前需噴灑本公司的界面劑，進一步增加粘接強度。
<p style='color: rgb(51